Easy Barnwood

/Easy Barnwood
Easy Barnwood

Easy Barnwood

Easy Barnwood is the simple solution to reclaimed barnwood – a naturally beautiful product that is often plagued with problems. Reclaimed barnwood can be expensive, difficult to install, and can be full of hidden hazards. If not purchased from a reputable dealer, such as Capital City Millwork, you will find that most painted, reclaimed Barnwood is contaminated with lead paint, arsenic and mold from being exposed to the elements for years. If not kiln dried and tested for these toxins, reclaimed barnwood can be hazardous to your family’s health.

Easy Barnwood was created to capture the rustic, natural beauty of reclaimed Barnwood without the high cost, difficult
installation and risk to your family’s health.

How is Easy Barnwood Better?
 Half the cost of reclaimed Barnwood
 Installs three times faster than reclaimed Barnwood
 16’ Lengths that are T&G to make installation easier
 Matching Trim available
 Unique T&G design for blind nailing
 Eco-friendly water based finish
 1/3 the waste of reclaimed Barnwood
 Guaranteed to have no barnyard smells
 Guaranteed to be free of lead and arsenic
 Made in the USA

Download the Easy Barnwood product documentation!

Note

The rustic beauty of Easy Barnwood is created by its infinite variation in character and color. Please use our samples and literature as a general guide as every piece of Easy Barnwood is unique.

Note

The rustic beauty of Easy Barnwood is created by its infinite variation in character and color. Please use
our samples and literature as a general guide as every piece of Easy Barnwood is unique.

Commonly Asked Questions:

Easy Barnwood is a low to no maintenance product when used inside. As with all wood products, you can experience some color change over time.
Interior walls & ceilings, man caves & basements, three season rooms, interior barn doors, porch ceilings, covered outdoor living areas and commercial interiors.
No. Easy Barnwood is not recommended for exterior siding or areas exposed to the weather.
No. Easy Barnwood should never be exposed to the weather, so there is no need for a warranty.
No. You should go to your nearest paint store and purchase a stain that is close in color.
Yes. The trim comes in 8’ lengths. The actual thickness is 11/6” and the width is approximately 3 1/2”. Add 15% for defects and cutting waste.
Add up the total square footage you want to cover. Add 15% for defects and cutting waste. Divide this number by nine. This will give you the number of 16’ pieces you will need for your project.
Yes. You will want to randomly stagger butt joints for the best appearance. Your project will look its best if you install 40% – 60% of the 16” T&G pieces without cutting into smaller pieces. We suggest selecting the boards with your favorite character to leave as your 16’ pieces. Then, depending on how much rustic character you prefer, cut out any undesirable characteristics, holes, or occasional end splits on the balance of your 16”pieces. Save and install the shorter pieces, as they are the key to randomly staggering butt joints. It’s easy and beautiful. Installation instructions are available.